Spacewalkers do repairs more quickly than expected — and stay dry

Spacewalking Astronaut

Two NASA spacewalkers started fixing the International Space Station’s cooling system more quickly than expected on Saturday, with no sign of the helmet-flooding problem that led NASA to outfit astronauts with snorkels for the first time.

Astronauts Rick Mastracchio and Mike Hopkins finished the first of three planned spacewalks in five and a half hours — an hour ahead of schedule. They moved so quickly that they got extra work done, stowing away a coolant pump module with a faulty valve to make room for its replacement. And if their next spacewalk goes as smoothly on Tuesday, they could dispense with the third outing.

“Really nice work, guys,” fellow NASA astronaut Doug Wheelock told the dynamic space duo from Mission Control. Wheelock was involved in a similar pump replacement operation in 2010.

Last week’s valve malfunction cut the station’s cooling capability in half, forcing mission managers to shut down non-critical systems on the $100 billion-plus orbital outpost. Ground controllers couldn’t get the valve back in service by remote control, which led to the plan for three spacewalks.

Worries about water
Replacing the refrigerator-sized pump module is one of the station’s expected maintenance tasks — but the job has been complicated by the fact that an Italian spacewalker, Luca Parmitano, almost drowned in July when water pooled in the helmet of his U.S.-made suit.

That incident led NASA to suspend U.S. spacewalks while the station’s crew and controllers worked to track down the source of the problem. They think they’ve identified the cause: previously undetected contamination that clogged up the system designed to remove moisture from the suit. And they gave a clean bill of health to the spacesuits Mastracchio and Hopkins are using

But just to be safe, the astronauts wore absorbent pads on their necks that should have picked up the first signs of excess moisture in the helmet — and they were primed to stop the spacewalk if those pads started feeling squishy. They also had jury-rigged snorkel tubes within easy reach of their mouths in the event that water started to cover their faces.

Mastracchio and Hopkins told Mission Control they didn’t feel a bit of squishiness, raising the confidence level for future spacewalks.

Three spacewalks, or two?
This was the seventh career spacewalk for Mastracchio — and the first one for Hopkins, who wore the suit that Parmitano used in July. During Saturday’s outing, they disconnected cables and fluid lines attached to the faulty pump module, and hooked up a jumper box to keep the liquid ammonia coolant from leaking out.

That took care of all the originally assigned duties. Then, with Mission Control’s go-ahead, they pulled out the pump module and hooked it onto a storage fixture. Japanese astronaut Koichi Wakata helped out from inside the station by operating the 58-foot-long (18-meter-long) robotic arm.

NASA spacewalker Mike Hopkins works outside the International Space Station on Saturday.

NASA spacewalker Mike Hopkins works outside the International Space Station on Saturday.

One of the potential perils that the spacewalkers faced was exposure to toxic ammonia. At one point, Mastracchio reported that some “very small flakes” of frozen ammonia floated out of one of the fluid lines and landed on his spacesuit. Fortunately, the ammonia contamination was “baked out” of the suit through exposure to sunlight.

Mission Control told the spacewalkers they could start preparations to install the spare pump module if they wanted to, but Mastracchio said he preferred to “call it a day.” The spacewalk, which was originally planned to last six and a half hours, ended at 12:29 p.m. ET — five hours and 28 minutes after it began.

During the next spacewalk, the astronauts are scheduled to install the spare pump module, which has been in storage on the space station’s exterior. Because they were able to work ahead on Saturday, they may be able to finish the repair job in two spacewalks and forget about the third one

The three spacewalks were initially set for Saturday, Monday and then Wednesday — which is Christmas Day. But late Saturday, NASA rescheduled the second spacewalk from Monday to Tuesday — which is Christmas Eve. In a statement, NASA said the extra day would give the crew time to resize a spare spacesuit for Mastracchio’s use.

“During repressurization of the space station’s airlock following the spacewalk, a spacesuit configuration issue put the suit Mastracchio was wearing in question for the next excursion — specifically whether water entered into the suit’s sublimator inside the airlock,” NASA said.

As a result, flight controllers decided to switch to the backup suit. NASA said the issue was not related to the water leak that caused so much trouble back in July.

In the foreground, NASA astronaut Rick Mastracchio helps guide the refrigerator-sized, 780-pound coolant pump module to its storage spot while standing on the end of the Initernational Space Station's robotic arm.

In the foreground, NASA astronaut Rick Mastracchio helps guide the refrigerator-sized, 780-pound coolant pump module to its storage spot while standing on the end of the Initernational Space Station’s robotic arm.

Repercussions weighed
The cooling system problem poses no immediate danger to the crew, but it does reduce the safety margin on the station. If the second coolant loop were to fail, urgent action would be required — and in a worst-case scenario, the station would have to be abandoned.

The situation already has forced NASA to delay the launch of a cargo resupply mission until Jan. 7 at the earliest. NASA sources say they are also studying whether last week’s glitch resulted in damage to Europe’s Columbus laboratory.

And as if the six-man crew didn’t have enough to worry about, NASA reported in an advisory that one of the toilets on the station has broken down.

In addition to Hopkins, Mastracchio and Wakata, the space station is home to three Russian cosmonauts: station commander Oleg Kotov, Mikhail Tyurin and Sergey Ryazanskiy. The 450-ton structure has been continuously occupied since 2000.

By: Alan Boyle
To view the original article CLICK HERE

Related Posts: 
  • Atafu Atoll, Tokelau, in the Southern Pacific Ocean
  • And here's what the capsule looks like without all the flashing lights. It's kind of gumdrop-shaped:
  • Virgin Galactic on the Tarmac
  • A SpaceX Falcon 9 rocket lifts off.
  • Orion Exploration flight test one
  • Photo of the moon from the International Space Station. Credit: NASA
  • Soyuz Liftoff
  • NASA's LADEE spacecraft was imaged above the surface of the Moon as seen by the Lunar Reconnaissance Orbiter
  • Spaceport Map
  • Photo by Mark Rademaker
    Faster than Light: Warp Drive - SpaceVision 2013
  • Viewing map
  • SpaceShipTwo
  • Spaceport America Company Locations
  • Microgravity Training
  • ISS
  • Mission Control
  • Dream Chaser
  • Waypoint2Space Zero Gravity Simulation Spaceflight Fundamentals
  • Viewing Map
  • Newton Engine
  • Spacewalking Astronaut
  • Launch Pad
  • Dream Chaser
  • Mars Landscape
  • Falcon 9 Liftoff
  • LADEE
  • F9R 1000m Fin Flight | Onboard Cam and Wide Shot
  • File picture of a Falcon 9 rocket carrying a small science satellite for Canada is seen as it is launched from a newly refurbished launch pad in Vandenberg Air Force Station. CREDIT: REUTERS/GENE BLEVINS
  • Falcon 9 First Stage Reentry Footage from Plane
  • Leaked Star Wars Episode VII Filmset Footage!
  • Time Capsule to Mars Press Conference (excerpts)
  • Stock Xcor Photo
  • Dream Chaser New Concept of Operations
  • Astronaut Tim Peake
  • Richard Branson: I Want You to Be an Astronaut
  • First SpaceX capsule to deliver to the ISS
  • Falcon 9 First Stage Return | ORBCOMM Mission
  • Space Shuttle on Plane
  • Commercial Spaceflight Federation
  • Cygnus Launch
  • ISS Crossing the Orlando Skyline
  • FAA Logo
  • Ashton Kutcher
  • Sochi Olympic Torch in Space
  • NASA Commercial interests
    Highlights from Commercial Flights to the International Space Station
  • Commercial Space Program Success
  • Cape Canaveral
  • Free Floating NASA Astronaut
  • Virgin Galactic Celebration
  • Virgin Galactic Spaceship2
  • SpaceX Dragon launch
  • PayPal Galactic: Aiming For The Final Frontier
  • NASA Johnson Style (Gangnam Style Parody)
  • Olympic Soyz
  • Zero Gravity training
  • WhiteKnight and SpaceShipTwo taking off
  • SNC's Dream Chaser First Free-Flight Approach-and-Landing Test
  • Cygnus detaching from ISS
  • US astronaut Karen Nyberg tweeted this striking photo of storm clouds above Ghana as seen from the International Space Station.on October 8, 2013. Credit: Karen Nyberg/NASA
  • Boeing CTS-100 Capsule in orbit
  • EVA from the Movie "Gravity"
  • Cygnus on Launchpad
  • SpaceShipTwo
  • Maven
  • SpaceX rocket Waiting to launch
  • Chinese Launch
  • SES-8 Patch
  • Falcon 9 launch
  • Moon landing
  • X-37B
  • Let's Create History Together
  • $75K 'Edge Of Space' Balloon Ride Gets FAA Approval | Animation
  • Bigelow
  • Chinese-Brazilian Rocket
  • Venus
  • Rocket on pad
  • Mojave Desert
  • ISS
  • Maven Launch
  • Silicon Valley entrepreneurs set sights on space travel
  • Solar Flare
  • VASIMR Orbital Sweeper for Space Debris Removal
  • International Space Station
  • Object tracking Map
  • ISS
  • Mars probe flyby
  • Antarctica Lab
  • NASA Launch Pad

Categories

Monthly Archive